Reads high and low side pressures so we can calculate superheat and subcooling and confirm the charge is correct.
AC replacement Greenville TX done right the first time
When your old unit quits for good, AC replacement Greenville TX is the fix that actually holds.
Serving greenville and nearby areas.
How big is the job?
System plus ducts
New equipment with duct repairs, added return, or a new line set
- 1. Swap only Condenser and coil changeout, existing ducts and line set in good shape
- 2. System plus ducts New equipment with duct repairs, added return, or a new line set
- 3. Full changeout Equipment, ducts, electrical, and permit planned in writing first
Drag the needle to compareTouch and drag the needle
- 27Services from one local team
- 20Areas served around greenville
- Measure firstLoad calculation before we quote
- Vacuum heldDeep vacuum before charging
What a replacement includes
Every replacement we quote covers the equipment and the work needed to make it run correctly.
Work order
AC Replacement- New condenser and coil: A matched outdoor condenser and indoor evaporator coil, sized to your home with a Manual J load calculation. We quote Carrier, Trane, Lennox, Goodman, Rheem, York, Bryant, American Standard, Mitsubishi Electric, Daikin, or LG equipment based on your budget and efficiency goals.
- Line set and pad: New or flushed line set with proper insulation, a level condenser pad, and a new electrical whip and disconnect where needed. We pressure test with nitrogen and pull a deep vacuum before charging.
- Refrigerant charge: We weigh in R-410A or R-32 refrigerant to the manufacturer's exact charge, then verify with superheat and subcooling readings. No guessing by gauge pressure.
- Thermostat and controls: A new thermostat wired and configured, or your existing smart thermostat reconnected. We walk you through schedules and setpoints before we leave.
- Drain line and float switch: We clear or replace the condensate drain line and confirm the float switch works. This is the part that floods ceilings when it clogs, so we do not skip it.
- Permit and haul-away: We pull the required Hunt County permit and remove the old condenser, coil, and any debris. You do not come home to a dead unit sitting in the side yard.
What the first visit covers
First visit
We inspect the condenser, coil, ducts, and electrical, measure static pressure, and run a load calculation.
Replacement at your home
Houses across Greenville, from older bungalows to newer builds.
Aging system
Compressor or coil failed on an older unit
Constant repairs
Capacitor and contactor failing every season
Hot rooms
House never reaches the setpoint in summer
High humidity
Air feels clammy even when it is cool
Replacement at your business
Offices, retail, and restaurants that cannot afford downtime.
Rooftop units
Failed compressors and aging rooftop equipment
Split systems
Office and retail splits past their service life
After-hours installs
Work scheduled around your business hours
What AC replacement Greenville TX really involves
A replacement is worth doing properly because the sizing, the vacuum, and the charge decide how long the new unit lasts. Get those right and you get 15 years of cooling. Get them wrong and you are back on the phone in three.
AC replacement Greenville TX means removing your old condenser, evaporator coil, and line set and installing a new matched system sized for your home. It is not a swap-and-go job. We run a Manual J load calculation, check duct sizing, verify the electrical disconnect and breaker, then set the new condenser on a pad, braze the line set, pull a vacuum with a vacuum pump, and weigh in R-410A or R-32 refrigerant to the exact charge. Every unit gets a leak detector pass and a 30-minute run test before we call it done.
Most folks in Greenville call us when the repair math stops making sense. A compressor failure on a 15-year-old unit, a refrigerant leak you have topped off three summers running, or a capacitor and contactor that keep failing in the same season all point the same direction. If you are typing AC unit replacement Greenville Texas into your phone while the house sits at 85 degrees, you are in the right place. We give you a straight answer on repair versus replace, usually the same day you call.
- What it is
- Removing an old system and installing a new matched one
- When it helps
- When repairs cost more than the system is worth
- What you get
- A sized, charged, tested system and a written scope
How our replacement process runs
Five steps, no surprises. You get a written scope, a firm number, and a clean install with the old equipment hauled off.
Tools and methods we use
Each method answers a different question. Together they leave very little to guess.
Pulls a deep vacuum on the line set before charging. Moisture left in the lines destroys compressors, so we hold the vacuum and verify.
Recovers refrigerant from the old system so nothing vents to atmosphere. Required under EPA Section 608 rules.
Finds refrigerant leaks in coils, line sets, and fittings that pressure testing alone can miss.
Tests capacitors, contactors, compressor windings, and amp draw to pinpoint electrical faults fast.
When Greenville homeowners replace
A 2003 system in a Downtown Greenville bungalow finally quits in July, and the family has a newborn at home.
We treat it as an emergency, pull a same-day slot, and install a right-sized single-stage system with a new line set and…
HomesA rental property off Woodruff Road has a unit that has needed refrigerant three summers running.
We locate the leak, document it with photos, and quote both the coil repair and a full replacement.
BusinessesA homeowner in the West End wants lower electric bills and better humidity control before next summer.
We run a Manual J load calculation, recommend a two-stage or variable-speed system, and pair it with an Ecobee thermostat.
HomesA small office on Haywood Road has a rooftop unit that fails during a heat wave and cannot keep the space comfortable.
We diagnose the rooftop unit, confirm the compressor is gone, and schedule a commercial replacement with minimal downtime.
Businesses
How replacement runs in Greenville
Greenville summers push equipment hard. Design temperatures here run near 98 degrees, and units that were marginal in May fail in August. Older homes in Downtown Greenville and the West End often have original ductwork with undersized returns, which raises static pressure and shortens equipment life.
Downtown Greenville
Older bungalows with original ductwork and small returns. We often add a return and resize the trunk line during replacement.
West End
Mix of renovated older homes and new builds. Attic installs are common, so we check attic insulation and radiant barrier before sizing.
Augusta Road
Larger homes with zoned systems. We verify damper operation and static pressure before quoting a replacement.
- Downtown Greenville
- West End
- Augusta Road
- Woodruff Road
- North Main
From problem to finished result.
Slide to compare the photo with an illustrative inspection view. It is generated from the photo, not a measurement.
Photo16-year-old unit in Downtown Greenville
Before: A 2008 single-stage system with a failing compressor, a refrigerant leak at the evaporator coil, and original ductwork with one undersized return.
After: We installed a 3-ton two-stage system with a new coil, line set, and an added return. Static pressure dropped from 0.9 to 0.55 inches of water column.
Rental unit off Woodruff Road
Before: A 2010 system that needed refrigerant every summer for three years. The tenant had called twice in one season, and the property manager was ready to replace rather than keep paying for recharges.
After: We replaced the condenser and evaporator coil with a matched 14.3-SEER2 system and a new drain line. No service calls in the following 12 months, and the tenant renewed the lease. The written quote matched the final invoice exactly.
Small office on Haywood Road
Before: A rooftop unit failed during a July heat wave.
After: We sourced a replacement rooftop unit sized to the actual load, scheduled the crane and install around business hours, and had the office cool again within two days. Amp draw on the new compressor came in well under the nameplate rating.
Problems a replacement actually solves
Some problems cannot be repaired out of an old system.
Compressor failed on a 15-year-old unit
A compressor replacement on an old system often costs half of a new unit and leaves you with the same tired coil, fan motor, and refrigerant…
Refrigerant leak you keep topping off
Refrigerant does not get used up, it leaks out.
House never gets below 80 in August
An undersized or failing system runs nonstop, spikes your electric bill, and still leaves you uncomfortable.
Capacitor and contactor failing every year
Repeated electrical failures usually mean the system is working beyond its design life.
Why homeowners replace instead of patch
A new system is not just cooler air. It is lower electric bills, fewer 2 a.m.
Lower summer power bills
A 16-SEER2 replacement against a dying 10-SEER unit can cut cooling costs by 30 to 40 percent.
No more emergency calls
Old systems fail on the hottest weekend of the year, every time.
Correct refrigerant and charge
We weigh in refrigerant by the ounce instead of guessing by gauge pressure. Overcharged or undercharged systems kill compressors early and freeze evaporator coils.
Better humidity control
A properly sized variable-speed or two-stage system pulls more moisture out of Greenville air than an oversized single-stage unit.
What replacement costs in Greenville
That covers equipment, line set, pad, disconnect, thermostat, permit, and haul-away.
Included
Quoted after a first look
- New condenser and coil
- Line set and pad
- Refrigerant charge
- Thermostat and controls
What changes the scope
Quoted after a first look
- System size and tonnage
- Efficiency rating
- Ductwork condition
- Line set and electrical
What you receive
Clear records you can keep and share.
Written scope
Model numbers, work items, and a firm total
Load calculation
Manual J sizing for your home on record
Install photos
Line set, pad, and electrical documented
Local experience you can lean on
That matters in Greenville because our summers push equipment harder than almost anywhere in the state.
Static pressure
Read at the return and supply to see if ducts are restricting airflow
Superheat and subcooling
Calculated from gauge readings to confirm the refrigerant charge is correct
Amp draw
Clamped at the compressor and fan motor to compare against nameplate ratings
Do we cover your part of greenville?
Type your ZIP or town to check. If it is not listed, call and ask.
greenville ZIP codes
- 75401
- 75402
Towns we serve.
Based in greenville and covering the places around it. Pick one for local details.
What Greenville homeowners say
Our 16-year-old unit died on a Friday in July. Greenville CoolCraft came out Saturday morning, gave us three options with real prices, and had a new Trane condenser and coil in by Monday afternoon. House was at 73 by dinner. They hauled the old unit off and cleaned up better than they found it.
We had been adding refrigerant every summer for three years. They found the leak in the evaporator coil, showed me the numbers on repair versus replace, and did not push. We went with the replacement.
I manage six rentals and needed two systems replaced in the same week. They scheduled both, kept me updated, and handled the permits. Tenants had no complaints. The written quotes matched the final invoices to the dollar, which almost never happens.
Frequently Asked Questions
Short answers for the first few minutes. The team can cover the rest.
Still have a question?
Describe what you are seeing and we will point you to the right next step.
(903( 304-5500The cost to replace AC unit Greenville Texas depends on tonnage, efficiency rating, whether the line set and ductwork need work, and whether you choose a single-stage or variable-speed system. We give you a written number before any work starts.
A standard residential replacement takes eight to ten hours, so most jobs are done in one day. If we are replacing ductwork, adding a return, or upgrading the electrical disconnect, plan on two days. Commercial rooftop units and multi-zone systems take longer. We confirm the timeline when we schedule.
If you are adding refrigerant every summer, that is a leak that will not fix itself. At that point replacement usually beats another repair.
We do. Greenville CoolCraft handles AC replacement across Greenville and Hunt County, including Downtown Greenville, West End, North Main, and Augusta Road. Call (903) 304-5500 and we will schedule a site visit, usually within 24 hours, and give you a written quote on the spot.
Related Services
Other services from the same team.
- Central Air Conditioning RepairCentral systems fail in predictable ways: a weak capacitor, a pitted contactor, a clogged drain line.
- Ductless Mini-Split AC RepairMini-splits from Mitsubishi Electric, Daikin and LG are common in additions and converted garages around Alta Vista.
- Heat Pump RepairHeat pumps handle both seasons here, so a reversing valve or defrost board failure hits twice as hard.
Get your AC replacement Greenville TX quote today
(903( 304-5500Call (903) 304-5500 and we will schedule a site visit, usually within 24 hours.
Get in touch with our crew
Call (903) 304-5500 and you will talk to someone who knows cooling, not a call center script. We answer weekdays from 8 a.m. to 6 p.m. If you are in ZIP 75401 or 75402, we are usually nearby.